CNY ¥277,891
常规
年限
2020
制造商
CATERPILLAR
型号
262D3
小时
2,823
序列号
ZB201879
状况
二手
库存号
MT36617A
描述
Auxiliary Hydraulics Flow - Standard Flow
Coupler Type - Hydraulic
Emissions Level - EPA - Tier4
Emissions Level - Japan - 2014 Regulation
Emissions Level - Korea - Korea-Tier4
Heater / Defroster
Ultra Low Sulfur Diesel Fuel
Equipment-certification-code: NCR
内视
空调
是
动力总成
Two-Speed
是
检查报告信息
GENERAL COMMENTS
GENERAL COMMENTS
Normal
PREPARE MACHINE INSPECTION
CHECK PRODUCT LINK
Normal
CHECK WITH CUSTOMER FOR OPERATOR COMPLAINTS
N/A
DOWNLOAD MACHINE FAULT CODES
Normal
IS MACHINE EQUIPPED WITH PL?
YES
IS PL ACTIVATED?
YES
IS PL FUNCTIONING PROPERLY?
Normal
LISTEN FOR UNUSUAL NOISES
Normal
OBSERVE ENGINE EXHAUST COLORS
Normal
PERFORM SAFETY/PREPARATORY INSPECTION
Normal
PREPARE THE MACHINE FOR THE INSPECTION
Normal
LOWER-LEVEL INSPECTION
BOGIE AXLES (MTL)
N/A
BOGIE WHEELS (MTL)
Normal
CHAIN DRIVE (SSL)
N/A
DRIVE CHAIN TENSION (SSL)
N/A
IDLER AXLES (FRONT AND REAR) (MTL)
N/A
IDLER WHEELS (FRONT AND REAR) (MTL)
Normal
RUBBER TRACKS (MTL)
N/A
SPROCKETS (MTL)
N/A
TIRES AND RIMS (SSL)
Normal
TRACK DRIVE FRAME AND/OR MACHINE FRAME (MTL/SSL)
N/A
TRACK DRIVES (MTL)
Normal
TRACK TENSIONER (MTL)
N/A
MIDDLE LEVEL INSPECTION
AIR CLEANER ASSEMBLY
Monitor
BATTERY AND BATTERY CABLES
Normal
BELTS, COMPRESSOR CLUTCH, AND PULLEYS
Monitor
CAB EXTERIOR
Normal
CAB INTERIOR
Action
CYLINDER HEAD AND VALVE COVER
Normal
ENGINE ACCESS DOOR
Normal
ENGINE MOUNTS
Normal
ENGINE OIL PAN
Normal
ENGINE WIRING HARNESS
Normal
EXHAUST MANIFOLD
Normal
FAN GUARD AND FAN
Normal
FUEL PRIMING PUMP, FUEL LINES, AND FUEL INJECTION PUMP
Normal
HORN AND/OR BACKUP ALARM
Normal
HYDROSTATIC PUMP AND MOTOR COMPARTMENT (MUST TILT CAB FOR ACCESS)
Normal
RADIATOR AND RADIATOR GUARD TILT MECHANISMS
Normal
RADIATOR CAP
Normal
RADIATOR GUARD
Normal
RADIATOR HOSES AND OIL COOLER LINES
Normal
RADIATOR, OIL COOLER, CONDENSER
Normal
STEPS AND HANDRAILS
Normal
TURBO CHARGER
Normal
WATER PUMP
Normal
WORK LIGHTS
Action
AIR CLEANER ASSEMBLY Comments
- Full of dust. Cleaned filter and reinstalled. Should be changed soon
BELTS, COMPRESSOR CLUTCH, AND PULLEYS Comments
AC compressor covered in wet dust. Located under the fuel fill so it's probably just residual. Monitor next inspection
CAB INTERIOR Comments
- Front door seal coming off. Should be replaced - Front wiper motor doesn't work -Windsheild washer fluid empty - RS top air vent broken - RS hyd lockout arm falls down. Won't hold itself up to allow operator to sit - wiper motor/window handle loose
RADIATOR, OIL COOLER, CONDENSER Comments
Dirty but good
WORK LIGHTS Comments
- Headlights don't work. Switch lights up but no lights functioning
IMPLEMENTS/ATTACHMENTS
AREA AROUND LIFT ARMS
Normal
BUCKET
N/A
BUCKET TIPS AND ADAPTERS
N/A
COUPLER
Action
COUPLER CYLINDER
Normal
CUTTING EDGES
N/A
LIFT CYLINDER
Normal
TILT CYLINDERS
Normal
BUCKET Comments
No bucket present with machine
COUPLER Comments
-Coupler pins do not travel full range of motion. Needs attention
SITE CONDITIONS
AIR QUALITY
Normal
ALTITUDE
Normal
AMBIENT TEMPERATURE
Normal
HAUL ROAD CONDITION
N/A
HAUL ROAD GRADE
N/A
HUMIDITY
N/A
MACHINE UTILIZATION
N/A
MAINTENANCE PRACTICES
N/A
PRIMARY INDUSTRIES
N/A
UNDERFOOT CONDITIONS
Normal
WORKING MATERIAL
N/A
HYDRAULICS PERFORMANCE CHECKS
CYLINDER DRIFT TEST (MAXIMUM ALLOWABLE MOVEMENT AFTER 1 MINUTE)
Normal
HYDRAULIC COUPLER SPEED TEST
Action
LIFT CYLINDER SPEED TEST
Normal
OPERATION OF TWO SPEED FUNCTION TEST: MACHINE SPEED DECREASES WHEN FAST MODE IS DEACTIVATED
YES
OPERATION OF TWO SPEED FUNCTION TEST: MACHINE SPEED INCREASES WHEN FAST MODE IS ACTIVATED
YES
TILT CYLINDER SPEED TEST
Normal
TRACKING OF MACHINE (DRIFT) TEST (MAXIMUM ALLOWABLE DRIFT AFTER 30.5M (100FT) OF TRAVEL
Normal
HYDRAULIC COUPLER SPEED TEST Comments
Coupler not releasing fully