CNY ¥1164,095
常规
年限
2003
制造商
CATERPILLAR
型号
14H
小时
14,666
序列号
ASE00495
状况
二手
库存号
CON0957
描述
Auto Shift
Drive - Tandem
Moldboard Size - 16'
Pushblock
Radio - Bluetooth
Ripper - Multi-Shank
ROPS - Enclosed
Steering Type - Wheel
Guard: Transmission
Mirrors
Defroster Fan
Ether Aid
Circle Clutch
Throttle Lock
Engine Was Replaced By Peterson Cat At 10: 070 Hours (6/29/2016)
AuxiliaryLighting
DifferentialLock
SeatType: Air Ride
类别特定
Grade Control Ready
是
Telematics
是
Exterior
驾驶室
封闭式
内视
空调
是
GPS Ready
是
发动机
引擎品牌
CATERPILLAR
引擎型号
3176C
检查报告信息
GENERAL APPEARANCE
Cleaning Required
Yes
S.O.S. Taken
Yes
Battery Box
Good
Cab or Canopy
Good
Crankcase Guard / Transmission Guard
Good
Decals
Good
Engine Enclosures
Good
Front Frame Welds
Good
Fuel Tank
Good
Grab Irons
Good
Hood
Good
Paint
Good
Plastic (Exterior)
Good
Pre-Cleaner Bowl
Good
Radiator Grill
Good
Rear Frame Welds
Good
Sheet Metal
Good
Steps / Ladder
Good
S.O.S. Taken Comments
Engine, hydro and trans sampled
SAFETY ITEMS
ROPS
Yes
Safety Decals In Place / Legible
Yes
Back Up Alarm
Good
Horn
Good
Parking Brake - SAFETY ITEMS
Good
Safety Locks / Pins
Good
Seat Belt / Date
Good
Seat Belt / Date Comments
3" seatbelt dated 12/2022
OPERATOR STATION
Current O&MM
Yes
Current Parts Manual
Yes
Current Safety Manual
Yes
Air Conditioner - OPERATOR STATION
Fair
Dash Console
Good
Door Latches / Seals
Good
EMS Panel / Warnings
Good
Floor Boards / Mats
Good
Gauges
Good
Glass/Mirrors
Good
Headliner
Good
Heater
Good
Interior Lights
Good
Meter Replaced / Working
Good
Monitoring Panel / Display
Good
Radio Type & Condition
Good
Seat Cushion / Arm Rest
Good
Seat Suspension Type / Condition
Good
Switches
Good
Windshield Wipers
Good
Notes - OPERATOR STATION 1
One active service code
Air Conditioner - OPERATOR STATION Comments
Left side A/C vent has been knocked out of place. A/C doesn't blow very cold or hard because of it
Windshield Wipers Comments
Unable to test sprayers, empty on washer fluid
ENGINE
Blow By
No
Compression in Radiator
No
Emissions Decal Legible
Yes
Fluid Levels OK?
Yes
Has Engine been rebuilt?
Yes
Knocking
No
Oil Leaks
Yes
Pre Lube System
No
Water in Oil
No
Air Cleaners
Good
Anti-Freeze Color / Level
Good
Engine Supports
Good
Exhaust / Muffler / Stack
Good
Fuel Injection System
Good
Governor / Control
Good
Oil Filter Condition / Service Hours
Good
Operating Condition - ENGINE
Good
Turbocharger / Blower
Good
Notes - ENGINE
Engine was replaced by Peterson CAT at 10,070 hours(6/29/2016)
Oil Pressure (H/L/N)
Normal
Smoke Color (B/D/L/W)
Normal
Oil Leaks Comments
Visible leak from left side pump
Oil Filter Condition / Service Hours Comments
Machine was last serviced at 14299 hours. Current hours=14866 due for a 500 hour service
COOLING SYSTEM
Leaks
No
Belts / Pulleys - COOLING SYSTEM
Good
Coolers
Good
Fan
Good
Fan Drive / Type
Good
Hoses
Good
Radiator
Good
Shroud / Guards
Good
Water Pump
Good
ELECTRICAL, STARTING AND CHARGING SYSTEM
Active Codes
Yes
Signal Lights
Yes
Alternator
Good
Batteries / Cables
Good
Product Link / Condition
Good
Starter
Good
Wiring
Good
Work Lights
Poor
Active Codes Comments
Active service code
Signal Lights Comments
Rear right blinker is out. Front right blinker is also out
Work Lights Comments
Both rear work lights are non-op
TRANSMISSION
Leaks - TRANSMISSION
Yes
Transmission - Noisy
No
Case - TRANSMISSION
Fair
Controls - TRANSMISSION
Good
Cooler
Good
Lines / Fittings - TRANSMISSION
Good
Operating Condition - TRANSMISSION
Good
Pump - TRANSMISSION
Good
Seals
Fair
Temp / Pressure Gauges
Good
Transmission - Forward Shifts
Good
Transmission - Reverse Shifts
Good
Transmission Oil Filter Condition / Service Hours
Good
Valves
Good
Leaks - TRANSMISSION Comments
A large wet spot, as well as multiple wet hoses on right rear side of transmission case. Can't get access, belly pans will need dropped and further inspected
STEERING
Articulate P & B
Fair
King Pins
Good
Lines / Fittings
Good
Steering Column / Tilt
Good
Steering Cylinder
Good
Steering Frame
Good
Steering Linkage
Good
Steering Pump
Good
Steering Valve
Good
Tie Rods / Rod Ends
Good
Wheel / Joystick
Good
Wheel Lean Cylinder - STEERING
Good
Articulate P & B Comments
Moderate play
BRAKE
Accumulators
Good
Brake Linkage
Good
Compressor
Good
Control Valve
Good
Lines
Good
Parking Brake Operation
Good
Pedal
Good
Service Brake Operation
Good
DRIVECHAIN / TANDEMS
Differential
Good
Differential Lock / Operation
Good
Drivetrain / Tandem Leaks
Good
Oscillating Hubs / Oil Level
Good
Planetary
Good
Tandem Housing / Drive Chains
Good
Wheel Lugs & Rims
Good
HYDRAULICS
Leaks - HYDRAULICS
Yes
Blade Cushion
Fair
Circle Drive Box
Good
Circle Side Shift Cylinder
Fair
Cylinder Mounts / Pins
Fair
Hydraulic Lines / Fittings
Good
Hydraulic Oil Filter Condition / Service Hours
Good
Hydraulic Pump
Good
Hydraulic Valves
Fair
Lift Cylinders
Fair
Linkage
Good
Operating Condition - HYDRAULICS
Good
Pump Drive Shaft
Good
Saddle Pin / Actuator
Good
Side Shift Cylinder
Fair
Tank / Sight Glass / Cap
Fair
Tip Cylinder
Fair
Circle Side Shift Cylinder Comments
Moderate play in circle side shift cylinder
Cylinder Mounts / Pins Comments
Upper lift cylinder yokes both have minor play. Both lift cylinder balls and caps have moderate play and need shimmed.
Hydraulic Valves Comments
Lower left hydraulic control valve shows signs of a possible leak, need steam cleaned and further inspected. Lower right side hydraulic control valve has multiple leaks and has been leaking for an extended period of time.
Lift Cylinders Comments
Left side lift cylinder slowly bleeds and loses pressure causing blade to drop
Side Shift Cylinder Comments
Moderate-severe play in anchor pin
Tank / Sight Glass / Cap Comments
Main tank transfer hose shows signs of a leak in multiple locations
BLADE
Circle A Frame
Good
Circle Frame
Good
Circle Shoes / Inserts
Poor
Cutting Edge
Fair
Cylinder Balls / Caps
Fair
Face / Moldboard
Fair
Frog / Base Edge
Good
Moldboard Tip Brackets / Inserts
Fair
Ring Gear
Fair
Saddle
Good
Tip Bracket Pivots / Bearings
Fair
Circle Shoes / Inserts Comments
All circle shoe inserts and wear pads are heavily worn, loose or missing, and need replaced.
Cutting Edge Comments
Both ends are wearing unevenly
Cylinder Balls / Caps Comments
Cylinder balls and caps have moderate wear and need shimmed.
Face / Moldboard Comments
Moldboard is heavily worn on left side and center, has began to wear into bolts.
Moldboard Tip Brackets / Inserts Comments
All brass is worn and needs replaced.
Tip Bracket Pivots / Bearings Comments
Moderate play.
RIPPER
Beam
Good
Brackets / Studs
Good
Cylinders
Fair
Frame
Good
Lines / Fittings - RIPPER
Good
Pins / Bushings
Fair
Shanks / Ripper (GET)
Good
Cylinders Comments
Minor play in cylinder yoke, needs shimmed.
Pins / Bushings Comments
All pins and bushings have moderate play, and need shimmed.
Shanks / Ripper (GET) Comments
7 total ripper shanks,
TIRES
Radial
Yes
Left Center
Serial: Yokohama Radial RB31;TreadDept: 39/32;PercentageLeft: 90;ReCapped: No;TreadCutsChucks: No;SideCutsSection: No
Left Front
Serial: Yokohama Radial RB31;TreadDept: 25/32;PercentageLeft: 58;ReCapped: No;TreadCutsChucks: No;SideCutsSection: No
Left Rear
Serial: Yokohama Radial RB31;TreadDept: 39/32;PercentageLeft: 90;ReCapped: No;TreadCutsChucks: No;SideCutsSection: No
Right Center
Serial: Yokohama Radial RB31;TreadDept: 39/32;PercentageLeft: 90;ReCapped: No;TreadCutsChucks: No;SideCutsSection: No
Right Front
Serial: Yokohama Radial RB31;TreadDept: 25/32;PercentageLeft: 58;ReCapped: No;TreadCutsChucks: No;SideCutsSection: No
Right Rear
Serial: Yokohama Radial RB31;TreadDept: 40/32;PercentageLeft: 93;ReCapped: No;TreadCutsChucks: No;SideCutsSection: No
Notes - TIRES
Both front tires have light weather cracking but should run out okay
Tire Size - TIRES
20.5R25
COMMENTS, MISC. REPAIRS, GENERAL REMARKS
comment 1
Machine runs and operates, all functions perform normally. With acception to repairs needed and engine being replaced, machine is in overall fair condition.