USD $113,000
Machine Location:241 Expo RoadFishersville, Virginia, USA 22939(Opens in a new tab)
Seller Information
View Seller Information
General
Year
2012
Manufacturer
CATERPILLAR
Model
D6N LGP
Hours
11,064
Serial Number
PBA00461
Condition
Used
Stock Number
5033250T0
Description
Blade Tilt - Dual Tilt
Blade Type - Angle
Hand and Foot Control
Online Owner's Manual
Radio - AM FM Radio
ROPS - Enclosed
Steering Type - Joystick
Ultra Low Sulfur Diesel Fuel
Engine Enclosures
Equipment-certification-code: NCR
Pressure: Low Ground (LGP)
AuxiliaryLighting
SeatType: Air Ride
Category Specific
Grade Control Ready
Yes
Telematics
Yes
Chassis
Drawbar
Yes
Interior
A/C
Yes
GPS Ready
Yes
Powertrain
Differential Steering
Yes
Inspection Information
GENERAL APPEARANCE
Cleaning Required
Yes
S.O.S. Taken
Yes
Battery Box
Poor
Belly Pans
Good
Bumper
Good
Cab or Canopy
Fair
Counterweight
Poor
Decals
Good
Draw Bar
Good
Engine Enclosures
Fair
Fenders
Poor
Fuel Tank
Poor
Grab Irons
Good
Guards
Poor
Hard Nose P&B
Good
Hood
Good
Main Frame Welds
Good
Paint
Fair
Pre-Cleaner Bowl
Good
Radiator Grill
Good
Screens
Poor
Sheet Metal
Good
Steps / Ladder
Good
Sweeps
Poor
Transmission Guard
Good
Battery Box Comments
Battery box is dirty/ Positive terminal is damaged/ Negative cable has been rubbed through to bare wire./Battery hold down broken weld.
Cab or Canopy Comments
Cab is dirty/Trash and duct tape packed behind dash
Counterweight Comments
Machine is not equipped with a counterweight
Engine Enclosures Comments
Right and left side engine compartment door latches are worn and cause doors to rattle.
Fenders Comments
Fender doors do not hang straight/ Right side door will not latch/ Dirt build up inside compartments.
Fuel Tank Comments
Lots of rust inside of fuel tank
Guards Comments
Right and left side engine compartment door latches are worn and cause doors to rattle.
Paint Comments
Machine paint is faded
Screens Comments
Machine not equipped with screens
Sweeps Comments
Machine is not equipped with sweeps
SAFETY ITEMS
ROPS
Yes
ROPS Certification Plate
Yes
Safety Decals In Place / Legible
Yes
Back Up Alarm
Poor
Horn
Good
Parking Brake - SAFETY ITEMS
Good
Seat Belt / Date
Good
Back Up Alarm Comments
Back up alarm is not working
Seat Belt / Date Comments
Seat belt must be replaced in one year
OPERATOR STATION
Current O&MM
Yes
Current Parts Manual
Yes
Current Safety Manual
Yes
Air Conditioner
Good
Dash Console
Fair
Door Latches / Seals
Good
EMS Panel / Warnings
Good
Floor Boards / Mats
Fair
Gauges
Good
Glass/Mirrors
Good
Headliner
Fair
Heater
Good
Interior Lights
Good
Meter Replaced / Working
Good
Monitoring Panel / Display
Good
Radio Type & Condition
Fair
Seat Cushion / Arm Rest
Fair
Seat Suspension Type / Condition
Good
Switches
Good
Windshield Wipers
Poor
Current O&MM Comments
Manuals are worn
Current Parts Manual Comments
Manuals are worn
Current Safety Manual Comments
Manuals are worn
Air Conditioner Comments
Air flow is weak out of the vents
Dash Console Comments
Trash and duct tape packed behind dash
Floor Boards / Mats Comments
Floor mat is dirty
Headliner Comments
Headiner is dirty
Heater Comments
Air flow is weak out of the vents
Radio Type & Condition Comments
FM radio/Radio has a lot of static
Seat Cushion / Arm Rest Comments
Seat is dirty
Seat Suspension Type / Condition Comments
AIR
Windshield Wipers Comments
Blades are worn out
ENGINE
Blow By
No
Compression in Radiator
No
Emissions Decal Legible
No
Fluid Levels OK?
Yes
Has Engine been rebuilt?
Yes
Knocking
No
Oil Leaks
No
Pre Lube System
No
Water in Oil
No
Air Cleaners
Fair
Anti-Freeze Color / Level
Good
Engine Supports
Good
Exhaust / Muffler / Stack
Good
Fuel Injection System
Good
Governor / Control
Good
Oil Filter Condition / Service Hours
Good
Operating Condition - ENGINE
Good
Turbocharger / Blower
Good
Oil Pressure (H/L/N)
Normal
Has Engine been rebuilt? Comments
Engine was rebuilt 2500 hours ago
Air Cleaners Comments
Engine air filter is dirty
EMISSIONS
Leaks / Type
No
After Treatment System
Good
DPF Condition / Hours Changed
Poor
Diesel Exhaust Fluid (DEF) Level
Machine does not require DEF
DPF Condition / Hours Changed Comments
Unknown when DPF was changed.
COOLING SYSTEM
Folded Core Radiator
No
Leaks - COOLING SYSTEM
Yes
Modular Radiator
No
Sand Blast Grid
No
Standard Radiator
Yes
Belts / Pulleys - COOLING SYSTEM
Good
Coolers
Poor
Fan
Good
Fan Drive / Type
Good
Hoses
Fair
Radiator
Poor
Shroud / Guards
Good
Water Pump
Good
Coolers Comments
Intercooler is full of dirt
Hoses Comments
Lower coolant hose small leak. oil cooler hoses are cracked
Radiator Comments
Radiator is full of dirt/ radiator support bracket is loose and missing bolt
ELECTRICAL, STARTING AND CHARGING SYSTEM
Active Codes
No
Block Heater
No
Ether Aid
Yes
Jump Start Terminal
No
Alternator
Good
Batteries / Cables
Poor
Pre-Heater
Good
Product Link / Condition
Fair
Starter
Good
Wiring
Good
Work Lights
Fair
Ether Aid Comments
No ether can is installed
Batteries / Cables Comments
Battery box is dirty/ Positive terminal is damaged/ Negative cable has been rubbed through to bare wire./Battery hold down broken weld.
Product Link / Condition Comments
Product link is installed on to the machine but is not showing that it is currently functioning
Work Lights Comments
Work light harnesses are working but have damaged wires
TRANSMISSION
Auto Shift
Yes
Hydrostatic
No
Leaks - TRANSMISSION
No
Multi Velocity Shift Program
No
Powershift
Yes
Traction Control
Yes
Transmission - Noisy
No
Case
Good
Controls - TRANSMISSION
Good
Cooler
Good
Lines / Fittings - TRANSMISSION
Good
Operating Condition - TRANSMISSION
Fair
Pump - TRANSMISSION
Good
Seals
Good
Temp / Pressure Gauges
Good
Torque Converter (Stall Speed)
Fair
Transmission - Forward Shifts
Fair
Transmission - Reverse Shifts
Fair
Transmission Oil Filter Condition / Service Hours
Poor
Valves
Good
Operating Condition - TRANSMISSION Comments
Unable to get transmission through all the gears.
Torque Converter (Stall Speed) Comments
Unable to do a torque converter stall on machine
Transmission - Forward Shifts Comments
Transmission is only running in gear 1.5 or 2.5 forward
Transmission - Reverse Shifts Comments
Transmission is only running in gear 1.5 or 2.5 reverse
Transmission Oil Filter Condition / Service Hours Comments
Unknown when transmission filter was last changed
STEERING
Differential Steer
Good
Differential Steering Controls
Good
Pump / Motor
Good
Steering Clutch
Poor
Steering Linkage
Poor
Steering Operating Condition
Good
Steering Valve
Good
Steering Clutch Comments
Machine is not equipped with steering clutches
Steering Linkage Comments
Machine is not equipped with steering linkage
BRAKE
Parking Brake Operation
Good
Service Brake Operation
Good
HYDRAULICS
Leaks - HYDRAULICS
Yes
Angle Cylinder
Poor
Control Linkage - HYDRAULICS
Good
Hose Lines
Poor
Hydraulic Oil Filter Condition / Service Hours
Good
Hydraulic Valves
Good
Lift Cylinders
Poor
Mounts / Yokes
Poor
Overall Operating Condition
Good
Pumps
Good
Tank / Sight Glass / Cap
Poor
Tilt Cylinder
Poor
Leaks - HYDRAULICS Comments
Leaking hose under engine in belly pans
Angle Cylinder Comments
Angle cylinder has excessive play in both rod and barrel ends.
Hose Lines Comments
Multiple hoses show excessive wear
Hydraulic Oil Filter Condition / Service Hours Comments
131 hours since hydraulic oil filter was changed.
Lift Cylinders Comments
Both have excessive pin play in both rod and barrel ends.
Mounts / Yokes Comments
Front trunnion ball has excessive play
Tank / Sight Glass / Cap Comments
Cap is broken and not sitting correctly on the tank
Tilt Cylinder Comments
Right side tilt cylinder barrel end has excessive play
BLADE
Back of Blade
Fair
C Frame / Mounts / Bearings
Poor
Cutting Edge & Bits
Fair
Face / Moldboard
Fair
Knuckle
Poor
Pins
Poor
Push Arm
Poor
Single Tree
Poor
Spill Rack
Poor
Stabilizer Link
Poor
Tilt Arms
Poor
Tower
Poor
Trunnions
Poor
Back of Blade Comments
Back of blade has been repaired before.
C Frame / Mounts / Bearings Comments
C-frame has excessive play
Cutting Edge & Bits Comments
End bits and cutting edges are showing wear.
Face / Moldboard Comments
Face has been repaired before
Knuckle Comments
Knuckle has excessive play
Pins Comments
Pins have excessive play in there bores
Push Arm Comments
Machine is not equipped with push arms
Single Tree Comments
Machine is not equipped with a single tree
Spill Rack Comments
Machine is not equipped with a split rack
Stabilizer Link Comments
Stabilizer link has excessive play
Tilt Arms Comments
Tilt cylinder pins have excessive play in there bores
Tower Comments
Machine is not equipped with towers
Trunnions Comments
Trunnion ball has excessive play
RIPPER / GRAPPLE / WINCH
Hydraulic Winch
No
Mechanical Winch
No
Beam / Frame
Poor
Brackets / Studs
Poor
Brakes / Gears
Poor
Control Linkage
Poor
Drum / Clevis
Poor
Freespool
Poor
Lines / Fittings - RIPPER / GRAPPLE / WINCH
Poor
Operates Forward
Poor
Operates Reverse
Poor
Pins & Bushings
Poor
Pump
Poor
Ripper Lift Cylinder
Poor
Ripper Tilt Cylinder
Poor
Seals / Case
Poor
Shanks / Get
Poor
Hydraulic Winch Comments
Machine is not equipped with a ripper or winch
Mechanical Winch Comments
Machine is not equipped with a ripper or winch
Beam / Frame Comments
Machine is not equipped with a ripper or winch
Brackets / Studs Comments
Machine is not equipped with a ripper or winch
Brakes / Gears Comments
Machine is not equipped with a ripper or winch
Control Linkage Comments
Machine is not equipped with a ripper or winch
Drum / Clevis Comments
Machine is not equipped with a ripper or winch
Freespool Comments
Machine is not equipped with a ripper or winch
Lines / Fittings - RIPPER / GRAPPLE / WINCH Comments
Machine is not equipped with a ripper or winch
Operates Forward Comments
Machine is not equipped with a ripper or winch
Operates Reverse Comments
Machine is not equipped with a ripper or winch
Pins & Bushings Comments
Machine is not equipped with a ripper or winch
Pump Comments
Machine is not equipped with a ripper or winch
Ripper Lift Cylinder Comments
Machine is not equipped with a ripper or winch
Ripper Tilt Cylinder Comments
Machine is not equipped with a ripper or winch
Seals / Case Comments
Machine is not equipped with a ripper or winch
Shanks / Get Comments
Machine is not equipped with a ripper or winch
UNDERCARRIAGE
Pins & Bushings Turned?
No
Guiding Guard - Left
Poor
Guiding Guard - Right
Poor
Track Frame - Left
Good
Track Frame - Right
Good
Bottom Rollers
Bottom rollers show excessive wear
Carrier Rollers
Carrier rollers show excessive wear
Equalizer Bar
Equalizer bar pins have excessive play
Idlers / Type
Front idlers have a sharp outside edge
Segments
Sprocket segments show excessive wear
Pins & Bushings Turned? Comments
Pin and bushings need be turned on both sides
Guiding Guard - Left Comments
Left side guard is showing excessive wear
Guiding Guard - Right Comments
Right side guard is showing excessive wear
FINAL DRIVES
Magnetic Plugs Removed & Checked?
Yes
Housings, Left
Good
Housings, Right
Good
Planetaries / Differential, Left
Good
Planetaries / Differential, Right
Good