2023 IROCK TS520

2023

IROCK

899

TS520

79550

Bekas

230803 SP27

FEATURES "FEED CONVEYOR... Belt width 48” (1200 mm) Belt spec Plain 500/3 6+3 Drive drum dia. 13.1” (335 mm) Tail drum dia. 12.5” (320 mm) Gearbox Bonfig 805 W2 Gearbox ratio 24.2 Gearbox torque 7000Nm cont, 12500Nm max Motor Danfoss Flow rate 19.2 GPM (72.6 LPM) Adjustable speed YES Maximum speed 18.75 rpm" "MAIN CONVEYOR... Belt width 1050mm (42"") Belt spec Chevron 400/3 6+1.5 Drive drum dia. 11.2” (285 mm) Tail drum dia. 10.6” (270 mm) Motor Danfoss Flow rate 26.7 GPM (101.2 LPM) Adjustable speed Maximum speed 126.5 rpm" "TAIL CONVEYOR... Stockpile height - track model 15’ – 3” (4.64 m) Belt width 48” (1200 mm) Belt spec Plain - 400/2 6+1.5 Drive drum dia. 285mm (11.2"") Tail drum dia. 270mm (10.6"") Motor Danfoss Flow rate 26.2 GPM (101.2 LPM) Maximum speed 126.5 rpm" "SIDE CONVEYOR... Stockpile height - track model 16’ – 9” (5.1 m) Belt width 32” (800 mm) Belt spec Chevron - 400/3 6+1.5 Drive drum dia. 11.2” (285 mm) Tail drum dia. 10.6” (270 mm) Motor OMT Flow rate 13.4 GPM (50.6 LPM) Adjustable speed YES Maximum speed 126.5 rpm Drum centers 33’ – 8” (10.275 m)" "SCREENBOX... 5’ x 20’ (1524 mm x 6100 mm) -top deck 5’ x 18’ (1524 mm x 5490 mm) -Bottom deck Bearing type NSK 110 mm bore Screens - top deck 5' x 4' side tension - QTY 5 Screens - bottom deck 5' x 6' end tension - QTY 3 Tensioning - top deck side tension Tensioning - bottom deck Curved tension bar and adjuster Screen angle 20 to 30 deg Screen motor DBH MCC2213 (85.7 cc/rev) Drive system Direct drive with HRC180 coupling Hydraulic flowrate 26.7 GPM (101.2 LPM) Speed adjustable YES - Pressure compensated FCV Screen stroke adjustable 6 – 10 mm maximum Screen shaft speed 1130 - 950 rpm Screen 'g' force 4.29 - 5.05 g" "POWERUNIT AND HYDRAULICS... Engine CAT® 4.4 Engine speed 2,200 rpm Flywheel Pump 1 DBH 5046,5046,5033 LH PTO Pump 2 DBH 5023,5023,19.5 Total system flow 110.7 GPM (419 L) Hydraulic tank capacity 166 gal (630 L) Hydraulic tank ratio 1.51 : 1 Hydraulic Oil cooler " "CONTROLS... Emergency stops 6 off, 1 feeder, 2 powerunit RH&LH, 2 chassis front RH&LH, 1 Walkway Chassis cabling Armored cable Start Siren - 10 sec delay Engine shutdowns: Low oil pressure, High water temp, Air filter blockage (selectable), Fuel contamination, Low hydraulic tank level Engine room light Remote tipping grid - 2 function timed Radio control tracks Pendant track control - plugged in at feeder end" "TRACKS... Width 19.7” (500 mm) Length 12’ – 6” (3.8 m) crs Height 31.4” (798 mm) Gearbox Bonfiglioli 709 Ratio 148:1 Motor Rexroth 90 Speed max 0.71 mph (1.14 kph) Flow rate 26.7 GPM (101.2 LPM) Attachment to chassis - Bolt On for quick change" EXCLUDES: Freight, setup or installation, screen media or its installation, taxes, fees or permits.